Fresh Juice for a Red Club Car DS: Six New T-875 Batteries in Canyon Lake
Six new Continental T-875 8-volt batteries installed on a red Club Car DS at the Canyon Lake shop.
Recent Work
Plugged In Again: A New Charging Receptacle for a Yellow GEM in Our Canyon Lake Shop
New charging receptacle installed on a yellow GEM utility vehicle at the Canyon Lake shop.
A Surprise Leak Under the Back of Carol's Cart in Canyon Lake
Driver-side axle bearing and seal plus a leaking differential cover replaced on a Canyon Lake cart.
Whoa, Workhorse: New Brakes for Mark's Cushman Hauler Pro in Corona
Both brake assemblies, two drums, and both brake cables replaced on a 2016 Cushman Hauler Pro in Corona.
The Club Car That Wouldn't Budge: A Battery Mystery in Canyon Lake
Mixed 6V battery in an 8V pack and a burned-off terminal left a 2000 Club Car DS dead in Canyon Lake; two T-875s and new ends fixed it.
Four Tires That Wouldn't Hold Air: Fixing the Real Cause on a 6-Passenger Cart in Corona
Curb-rashed wheel edges sanded smooth and four new tires installed on a six-passenger cart in Corona.
All or Nothing: Tracking Down a Full-Speed-Only 2003 E-Z-GO TXT in Menifee
2003 E-Z-GO TXT stuck at full speed only in Menifee; ITS tested good and a new controller was recommended.
Six Red Flashes: Why Frank's E-Z-GO Wouldn't Charge in Murrieta
Murrieta E-Z-GO that wouldn't charge: pack at 40V with one battery at 6V, PowerWise flashing six red (too low to charge).
Kill Switch Delete on a Lifted Six-Seat Cart in Canyon Lake
Failed kill switch removed from a lifted six-seat cart at the Canyon Lake shop; the cart now starts and runs on the key alone.
E-Z-GO Battery, Voltage Reducer and Solenoid Repair in Canyon Lake
Canyon Lake E-Z-GO that would not charge or run: two weak batteries replaced, a voltage reducer added and a melted main solenoid replaced; the cart now runs with no fault codes.
